STATE CHEMICAL MFG CO -- RAPID-WRENCH  -- 8030-00N061597
<pre>=====================  Product Identification  =====================

Product ID:RAPID-WRENCH
MSDS Date:02/01/1994
FSC:8030
NIIN:00N061597
=== Responsible Party ===
Company Name:STATE CHEMICAL MFG CO
Address:3100 HAMILTON AVE
City:CLEVELAND
State:OH
ZIP:44114-3701
Country:US
Info Phone Num:216-861-7114
Emergency Phone Num:216-861-7114
CAGE:53798
=== Contractor Identification ===
Company Name:STATE CHEMICAL MANUFACTURING CO.
Address:3100 HAMILTON AVENUE
Box:City:CLEVELAND
State:OH
ZIP:44114-3701
Country:US
Phone:216-861-7114
CAGE:53798

=============  Composition/Information on Ingredients  =============

Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT

Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED (SEV),HEAVY
    PARAFFINIC; (PETROLEUM OIL)
CAS:64742-54-7
RTECS #:PY8035501
Fraction by Wt: 10%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)

Ingred Name:GRAPHITE
CAS:7782-42-5
RTECS #:MD9659600
Fraction by Wt: <5%
OSHA PEL:15 MPPCF
ACGIH TLV:2 MG/M3 RDUST

Ingred Name:COPPER (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 10%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)
    (CERCLA)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 55%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM, A2
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:ACUTE: A HIGH CONCENTRATION OF VAPORS
    IN A CONFINED AREA ARE ANESTHETIC. MAY CAUSE LIGHT-HEADEDNESS,
    DIZZINESS AND POSSIBLE NAUSEA. CONTAINS PETROLEUM DISTILLATES.
    HARMFUL OR FATAL IF SWALLOWED. MAY I RRITATE SKIN AND UPPER
    RESPIRATORY SYSTEM. CHRONIC: PETROLEUM DISTILLATES SOLVENTS MAY
    AFFECT LIVER, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONOGRAPHS,
    SUPPLEMENT, VOL 7, PG 194, 1987: GROUP 2B. NTP 7TH ANNUAL REPORT ON
    (SUP DAT)
Effects of Overexposure:HLTH HAZ: KIDNEY & CNS. CHLOROCARBON MATERIALS
    HAVE PRODUCED SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN LAB
    ANIMALS AND COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
    (E.G., EPINEPHRINE)  MAY BE CONTRAINDICATED EXCEPT FOR
    LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
    CHLOROCARBONS .
Medical Cond Aggravated by Exposure:PREEXISTING LUNG, LIVER, KIDNEY AND
    SKIN DISORDERS. CARDIOVASCULAR PROBLEMS MAY BE AGGRAVATED BY
    OVEREXPOSURE TO METHYLENE CHLORIDE.

=======================  First Aid Measures  =======================

First Aid:INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING. CONTAINS
    PETROLEUM DISTILLATES. CONTACT MD IMMEDIATELY. INHALATION: REMOVE
    TO FRESH AIR. EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT
    LEAST 15 M INUTES. CONTACT MD. SKIN: WASH THOROUGHLY WITH SOAP AND
    WATER. IF IRRITATION OCCURS, CONTACT MD IMMEDIATELY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TOC
Flash Point:<20F,<-7C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
    FULL PROT EQUIP . WATER MAY BE INEFFECTIVE DUE TO SOLV NATURE OF
    THIS PROD, BUT CAN BE USED TO KEEP CANS COOL.
Unusual Fire/Explosion Hazard:EXPOSURE TO TEMPERATURE ABOVE 120F (49C)
    MAY CAUSE CANS TO VENT, RUPTURE OR BURST. THERMAL DECOMPOSITION
    PRODUCTS MAY INCLUDE HCL AND PHOSGENE .

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE IGNITION SOURCES AND VENTILATE AREA.
    ABSORB WITH OIL ABSORBENT, SAND OR VERMICULITE. WASH ANY RESIDUE
    WITH SOAP AND A GOOD DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DANGER: DO NOT STORE AT TEMPS >120F.
    EXPOS TO DIRECT SUNLIGHT/HEAT MAY CAUSE CANS TO VENT,
    RUPTURE/BURST. DO NOT SPRAY NEAR FIRE/OPEN FLAME.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PRLNG/RPTD CONT
    W/EYES/SKIN. KEEP OUT OF REACH OF CHILDREN. DO NOT PUNCTURE/INCIN.
    READ & FOLLOW ALL LABEL DIRECTIONS & PREC BEFORE USING PROD. THESE
    PROD ARE INTENDED FO R INDUSTRIAL & INSTITUTIONAL (SUP DAT)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:AVOID BREATHING VAPOR OR SPRAY MIST. IF AREA NOT
    PROPERLY VENTILATED, WEAR NIOSH/MSHA APPROVED RESPIRATOR FOR
    PROTECTION AGAINST MATERIALS IN INGREDIENTS SECTION.
Ventilation:NORMAL LOCAL VENTILATION IS APPROPRIATE.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:KEEP A SOURCE OF CLEAN WATER NEARBY IN THE
    CASE OF ACCIDENTAL EYE CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CARCIN EXPLAN: CARCINS, 1994: ANTICIPATED TO BE CARCIN ANIMAL: LUNG,
    LIVER, SALIVARY, MAMMARY GLAND (TUMORS). OTHER PREC: USE ONLY. NOT
    FOR HOUSEHOLD USE/RESALE. NO SMKNG IN AREA OF USE. DO NOT USE IN 
    GEN VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURF. HEAT &/UV
    RADIATION MAY CAUSE FORMATION OF HCL &/PHOSGENE .

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:18.0F,-7.8C
Appearance and Odor:COPPER COLORED LUBRICANT, WITH A PETROLEUM ODOR
Percent Volatiles by Volume:67(WT)

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:EXPOSURE TO TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:BURNING OF THIS PROD MAY RESULT IN
    FORMATION OF CARBON DIOXIDE AND CARBON MONOXIDE, HYDROGEN CHLORIDE,
    PHOSGENE GASES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DO NOT INCINERATE. FOLLOW ALL FEDERAL, STATE,
    AND LOCAL REGULATIONS REGARDING WASTE DISPOSAL.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.